What is the difference between E4OD and 4R100?
The 4R100 was introduced as the replacement for the E4OD and was internally stronger for use in the Powerstroke Diesel trucks. While almost identical on the exterior, not all parts are interchangeable between these two units, so care must be exercised to insure compatibility.
Are all e40d the same?
The E4ODs are different between the gas and diesels. Not interchangeable.
How many miles will a 4R100 transmission last?
I consider the life of a 4R100 to be about 120K miles. If this truck you are looking at has 200K, them most likely it has had a new transmission at some point. I’ve heard of them lasting that long, but not very often. If it breaks, it will cost around 2000-2500 for a shop to rebuild it for you.
Who makes the best 4R100 transmission?
The most notable builders in the E4OD/4R100 world are Brian’s Truck Shop (better known as BTS) and John Wood Automotive. The unit shown below is a Street Performance E4OD from John Wood Automotive.
How much does a 4R100 transmission cost?
Replacement 4R100 Transmission Prices:
| Transmission | Street Smart Transmission | Dealer Retail |
|---|---|---|
| 4R100 / E4OD | 1775 | 3228 |
What years did Ford use the 4R100 transmission?
Ford 4R100 Transmission Specs
| Transmission: | Ford 4R100 |
|---|---|
| Predecessor: | E4OD |
| Model Years/Applications: | 1999 -2003 Ford Super Duty w/ 7.3L Power Stroke diesel |
| Case Material: | Aluminum |
| Max Input Torque*: | 1000 lb-ft |
How many gears does a 4R100 have?
Ford 4R100 Transmission Specs
| Transmission: | Ford 4R100 | |
|---|---|---|
| Features: | 4 | Four forward gears |
| R | Rear wheel drive applications | |
| 100 | 1000 lb-ft nominal max input torque capacity | |
Does a 4R100 have overdrive?
Yup, the 4r100 is 3 gears forward and overdrive and a converter lockup which essentially makes it feel like a 5 spd.
How much oil does a 4R100 hold?
The E4OD and 4R100 transmission system holds almost 18 quarts of ATF, and you must waste a couple of quarts to be sure you get it all purged and replaced, so buy 20 quarts of MERCON ATF [For the 4R100, use MERCON V].
How do you check 4R100 fluid level?
Insert dip stick and check fluid level. If level is low, add fluid to bring level to MIN mark on the dipstick. Make sure to check that both sides of the dipstick are level. If one side is noticeably higher than the other, the dipstick has picked up some oil from the dipstick tube.
How much transmission fluid does a Ford Excursion take?
6 quarts (with filter)When refilling, remove dipstick to provide adequate venting and allow oil to flow into crankcase. After refill, check oil level. Top off to proper level as needed.
What type of transmission fluid does a Ford F250 take?
Mobil 1 Synthetic Transmission Fluid Dexron/Mercon 1 Quart.